Document Type : Research Article
Authors
- Mahdi Pourbafrani 1
- Hossein Ghadamian 2
- Mohammad Aminy 1
- Meisam Moghadasi 3
- Masoud Mardani 3
- Mohammad Akrami 4
- Amir houshang Khaki 5
- Seyed Mohammad Kazem Sadr 4, 5
1 Department of Energy, Materials and Energy Research Center, Karaj, Iran.
2 ِDepartment of Energy, Materials and Energy Research Center, Karaj, Iran.
3 Department of Energy, Materials and Energy Research Center, Karaj, Iran
4 Department of Engineering, University of Exeter, Exeter, UK.
5 Department of Research & Development, Chamberlains Aqua Systems Limited, Southampton, UK.
Abstract
Evacuated tube solar collectors (ETSC) are widely utilized in both domestic and industrial solar water heaters (SWH) due to their commendable thermal performance and straightforward installation. However, a significant challenge associated with ETSC lies in the fact that half of the collector remains unexposed to sunlight. To overcome this limitation, parabolic reflectors can be employed as a viable solution. The primary objective of this study is to assess the performance of a compound parabolic concentrator (CPC) in conjunction with ETSC, taking into account a specific ratio between the areas of the CPC and ETSC. To achieve the desired configuration, the CPC was meticulously designed, fabricated, installed, and subsequently tested. Moreover, the energy performance of the absorber tube was scrutinized both with and without the integration of a parabolic trough collector. The experiments and data collection were conducted on two selected days for both the conventional ETSC device and the system incorporating the CPC. Meteorological data and operational conditions were measured and digitally stored for subsequent analysis. A noteworthy outcome of the study is the revelation that the energy efficiency of the system with a concentrator exhibited a notable improvement of 2.8% compared to the conventional system. Offline results further indicated that the performance of a single absorber tube with a concentrator increased by approximately 2.7 times when compared to the standard system. This suggests that the energy performance of the solar water heater, with a capacity of about 200 liters and featuring 7 absorber tubes with a concentrator, is comparable to that of the conventional system equipped with 18 absorber tubes.
Keywords
- Vacuum Tube Solar Water Heater
- Evacuated Tube Solar Collector
- Central Parabolic Concentrator
- Energy Performance
- Experimental Investigation
Main Subjects
- Budihardjo I, Morrison GL. (2009). Performance of water-in-glass evacuated tube solar water heaters. Solar Energy. 83(1):49-56. https://doi.org/10.1016/j.solener.2008.06.010
- Chai S, Yao J, Liang J-D, Chiang Y-C, Zhao Y, Chen S-L, et al. (2021). Heat transfer analysis and thermal performance investigation on an evacuated tube solar collector with inner concentrating by reflective coating. Solar Energy. 220:175-86. https://doi.org/10.1016/j.solener.2021.03.048
- Chen F, Liu Y. (2022). Model construction and performance investigation of multi-section compound parabolic concentrator with solar vacuum tube. Energy. 250:123887. https://doi.org/10.1016/j.energy.2022.123887
- Chen X, Yang X, Li M. (2022). Combining horizontal evacuated tubes with booster mirror reflector to achieve seasonal reverse output: Technical and experimental investigation. Renewable Energy. 188:450-64. https://doi.org/10.1016/j.renene.2022.02.041
- Chen F, Xia E-t, Bie Y. (2019). Comparative investigation on photo-thermal performance of both compound parabolic concentrator and ordinary all-glass evacuated tube absorbers: An incorporated experimental and theoretical study. Solar Energy. 184:539-52. https://doi.org/10.1016/j.solener.2019.04.036
- Deng C, Chen F. (2020). Preliminary investigation on photo-thermal performance of a novel embedded building integrated solar evacuated tube collector with compound parabolic concentrator. Energy. 202:117706. https://doi.org/10.1016/j.energy.2020.117706
- Durbin, J., Watson, G. S. (1950). Testing for Serial Correlation in Least Squares Regression, I, Biometrika. 37 (3–4), 409–428. https://doi.org/10.1093/biomet/37.3-4.409.
- Durbin, J.; Watson, G. S. (1971). Testing for serial correlation in least squares regression, III". Biometrika. 58 (1), 1–19. https://doi.org/10.2307/2334313.
- Fathabadi H. (2020). Impact of utilizing reflector, single-axis and two-axis sun trackers on the performance of an evacuated tube solar collector. International Journal of Green Energy. 17(12):742-755. https://doi.org/10.1080/15435075.2020.1798766
- Hossein Ghadamian, Meisam Moghadasi, Mojtaba Baghban yousefkhani, Masoumeh Javaheri, Abouzar Massoudi, Hajar Amiria (2024). Experimental investigation on a novel empirical parameter for simultaneous analysis of the temperature and concentration effects on fuel utilization coefficient of direct ethanol fuel cell, Renewable Energy, Volume 224, 120132, ISSN 0960-1481, https://doi.org/10.1016/j.renene.2024.120132.
- Ismail KAR, Teles MPR, Lino FAM. (2021). Comparative analysis of eccentric evacuated tube solar collector with circular and rectangular absorber working with nanofluid. Cleaner Engineering and Technology. 3:100105. https://doi.org/10.1016/j.clet.2021.100105
- King, M.L., 1992. Introduction to Durbin and Watson (1950, 1951) Testing for Serial Correlation in Least Squares Regression, Springe: I, II, Breakthroughs in Statistics. https://doi.org/10.1007/978-1-4612-4380-9_19.
- Kumar PM, Mylsamy K. (2020). A comprehensive study on thermal storage characteristics of nano-CeO2 embedded phase change material and its influence on the performance of evacuated tube solar water heater. Renewable Energy. 162:662-676. https://doi.org/10.1016/j.renene.2020.08.122
- Li Q, Gao W, Lin W, Liu T, Zhang Y, Ding X, et al. (2020). Experiment and simulation study on convective heat transfer of all-glass evacuated tube solar collector. Renewable Energy. 152:1129-1139. https://doi.org/10.1016/j.renene.2020.01.089
- Seidabadi, H. Ghadamian, M. Aminy, M. Moghadasi & S. Ghahremanian, (2022). Simulation and experimental investigation of an organic phase change material-based air-cooling system for industrial applications in the hot climate, Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 44:1, 796-816. https://doi.org/10.1080/15567036.2022.2050965.
- Mevada D, Panchal H, ElDinBastawissi HA, Elkelawy M, Sadashivuni K, Ponnamma D, et al. (2022). Applications of evacuated tubes collector to harness the solar energy: a review. International Journal of Ambient Energy. 43(1):344-61. https://doi.org/10.1080/01430750.2019.1636886
- Milani D, Abbas A. (2016). Multiscale modeling and performance analysis of evacuated tube collectors for solar water heaters using diffuse flat reflector. Renewable Energy. 86:360-374. https://doi.org/10.1016/j.renene.2015.08.013
- Moghadasi, M., Ghadamian, H., Moghadasi, M., Seidabadi, L. (2023). Prediction of outlet air characteristics and thermal performance of a symmetrical solar air heater via machine learning to develop a model-based operational control scheme—an experimental study. Environ Sci Pollut Res 30, 27175–27190. https://doi.org/10.1007/s11356-022-24169-0
- Pourbafrani, M., Ghadamian, H., Moghadasi, M. & Mardani, M. (2023) Design, Fabrication, and Experimental Study of a Low-cost and Accurate Weather Station Using a Microcontroller System. Journal of Renewable Energy and Environment (JREE), 10(4), 35-43. https://doi.org/30501/JREE.2023.383796.1551.
- Moghadasi, N. Izadyar, A. Moghadasi, H. Ghadamian. (2021). Applying machine learning techniques to implement the technical requirements of energy management systems in accordance with iso 50001: 2018, an industrial case study, Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 1–18. https://doi.org/10.1080/15567036.2021.2011989
- Moghadasi, H. Ghadamian, M. Khodsiani, M. Pourbafrani, (2022). A comprehensive experimental investigation and dynamic energy modeling of a highly efficient solar air heater with octagonal geometry, Solar Energy, Volume 242, Pages 298-311, ISSN 0038-092X, https://doi.org/10.1016/j.solener.2022.07.030
- Qiu S, Ruth M, Ghosh S. Evacuated tube collectors: (2015). A notable driver behind the solar water heater industry in China. Renewable and Sustainable Energy Reviews. https://doi.org/47:580-8.1016/j.rser.2015.03.067
- Sadeghi G, Safarzadeh H, Ameri M. (2019). Experimental and numerical investigations on performance of evacuated tube solar collectors with parabolic concentrator, applying synthesized Cu2O/distilled water nanofluid. Energy for Sustainable Development. 48:88-106. https://doi.org/10.1016/j.esd.2018.10.008
- Sasikumar SB, Santhanam H, Noor MM, Devasenan M, Ali HM. (2020). Experimental investigation of parallel type -evacuated tube solar collector using nanofluids. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects. 1-13. https://doi.org/10.1080/15567036.2020.1829201
- Shoaib Khanmohammadi, Mohammad Mehdi Baseri, Pouria Ahmadi, Abdullah A.A.A. Al-Rashed, Masoud Afrand, (2020). Proposal of a novel integrated ocean thermal energy conversion system with flat plate solar collectors and thermoelectric generators: Energy, exergy and environmental analyses, Journal of Cleaner Production, Volume 256, 120600, ISSN 0959-6526, https://doi.org/10.1016/j.jclepro.2020.120600.
- Teles MdPR, Ismail KAR, Arabkoohsar A. (2019). A new version of a low concentration evacuated tube solar collector: Optical and thermal investigation. Solar Energy. 180:324-39. https://doi.org/10.1016/j.solener.2019.01.039
- Wang Q, Shen B, Huang J, Yang H, Pei G, Yang H. (2021). A spectral self-regulating parabolic trough solar receiver integrated with vanadium dioxide-based thermochromic coating. Applied Energy. 285:116453. https://doi.org/10.1016/j.apenergy.2021.116453
- Xia E-T, Chen F. (2020). Analyzing thermal properties of solar evacuated tube arrays coupled with mini-compound parabolic concentrator. Renewable Energy. 153:155-67. https://doi.org/10.1016/j.renene.2020.02.011
- Yousef FathiAlmas, Hossein Ghadamian, Mohammad Aminy, Meisam Moghadasi, Hajar Amirian, Siamak Hoseinzadeh, Davide Astiaso Garcia, (2023). Thermo-economic analysis, energy modeling and reconstructing of components of a single effect solar–absorption lithium bromide chiller for energy performance enhancement, Energy and Buildings, Volume 285, 112894, ISSN 0378-7788, https://doi.org/10.1016/j.enbuild.2023.112894.